Loading...
HomeMy WebLinkAboutDocumentation_Regular_Tab 09_11/14/2019 Agenda Item #9. O.O, :,VV Regular Council zik STAFF MEMOq, P ., '`k ccuM`' Meeting: Regular Council - Nov 14 2019 Staff Contact: Matthew Hammond Department: Utilities TITLE Authorize Water Meters & Radio Transceivers Sole Source Purchase SUMMARY: The Utilities Department has a need to purchase water meters and radio transceivers in support of the Village's water meter replacement and Advanced Metering Infrastructure (AMI) initiative. The Village has approximately 5,100 water meters installed through the Utility Service Area. The majority of existing water meters within the system were installed 13 to 15 years ago. The typical lifespan of mechanical water meters, which are the type that the Village has used for many years, is between 10 and 15 years, at which point the register batteries begin failing at a high rate and meter accuracy degrades to a point it is economically advantageous to replace the meters. Over the past 4 years the Utilities Department has been proactively phasing in newer AMI compatible meters and to date has purchased more than 3,600 Sensus AMI compatible water meters, • approximately 2,675 of which are installed. The installed meters have been successfully operating to date, including during a three-month pilot with the Sensus AMI system. Because of this, Utilities staff recommends that the Village continue to use Sensus water meters to fully implement the AMI program and make this purchase under the Sole Source provision of the approved Village Purchasing Directives and Procedures. To complete the replacement of outdated water meters within the potable system and convert to an AMI based metering system the following water meter purchase is required: Item Quantity Unit Price Extended Price 3/4" Sensus iPERL Water Meter 1,217 $106.00 $129,002.00 1" Sensus iPERL Water Meter 136 $143.00 $19,448.00 1 1/2" Sensus Omni R2 Water Meter 10 $412.00 $4,120.00 1 1/2" Sensus Omni C2 Water Meter 28 $915.00 $25,620.00 2" Sensus Omni R2 Water Meter 2 $580.00 $1,160.00 2" Sensus Omni C2 Water Meter 77 $1,053.00 $81,081.00 3" Sensus Omni C2 Water Meter 13 $1,334.00 $17,342.00 6" Sensus Omni C2 Water Meter 2 $4,003.00 $8,006.00 Sensus SmartPoint (Single Port) 500 $120.00 $60,000.00 Sensus SmartPoint (Dual Port) 1,911 $135.00 $257,985.00 Total $603,764.00 410 The Village's approved Purchasing Directives and Procedures provides that the Village may acquire items that for all practical purposes can only be obtained from a single vendor, usually because of limiting technology, technological compatibility with existing systems or Items already in use by the Village or other unique qualities of the Items. Page 112 of 427 Agenda Item #9. Note: Utilities Department staff has compared meter pricing from multiple manufacturers across the •ountrY and negotiated favorable pricing with the proposed vendor. BUDGET INFORMATION: BUDGETED AMOUNT: AVAILABLE AMOUNT: EXPENDITURE AMOUNT: $750,000 $750,000 $603,764 Additional Budgetary Information: Funding Source(s): Note: Additional requests for this line item are 401-411-552.601 presented in this agenda. A resolution to modify the Water Fund (401) to fully fund the meter replacement and advanced metering system project is presented in this agenda. POTENTIAL MOTION / DIRECTION REQUESTED: Authorize sole source purchase of water meters and radio transceivers ATTACHMENTS: Core & Main Pricing Quote.ada iPERL Water Meters Data Sheet.ada OMNI R2 Data Sheet.ada OMNI C2 Water Meter Data Sheet.ada .SmartPoint Data Sheet.ada Page 113 of 427 Agenda Item #9. • O O O O O O O O o • O g o 0 0Q 0 O O O O — N O CA N CO N CO d' O I� O d CO O CO O f•--- 05 �O O I` C5 u N N CO CO N 63 Ef3 U4 64 EA ER ER V4 EA 0 0 0 0 0 0 0 0 r.+ 0 0 0 0 0 0 0 0 V O C'7 N O LC) vi 4 Cfi CD O CO e- LO M O d LO O O CO. O � r a 2 N CD (;)9- e9- 64 EF? 64 H} 64 CD 0 a a) • CD O O O ti CC 0 N M N N co Cf)N ti - NCO 410 -0 0 Wcc o L 0 CL CV N 2 N N CV N CV N a) ca ro ca co CO it J N N N N N N a w OLCL0 0 0 0 CO Z ZZZZZ • 2 2 2 2 2 2 c-6 ,- 000000 Page 114 of 427 Agenda Item #9. • O OO O0 o � L O co 0o Orn rn c5 co Lo N E9 413- O O .�+ O O C.) •O r � L a 2 69- E9 0 r N Q a 0 a1 L W C � o O • "L a 0 a o a) .- 1111 O O c in Page 115 of 427 Agenda Item #9. 1' iPERL Smart Water Meter Electromagnetic Flow Measurement System Sensus iPERL® smart water meters are designed to capture both lost water and lost revenue. The innovative magnetic technology delivers unmatched low flow registration and minimal pressure loss. With no moving parts, iPERL maintains its accuracy over a 20 year lifetime .aal ITIEs and is equipped with smart water alarms - delivering the intelligence you need to quickly resolve issues in the field. • The:°OR•_metes has an o erat. .-ange .-,r(7;11 qpm.0.'025 m3:^r!to 55 aom Industry Leading Performance The patented measurement technology of the iPERL water meter provides enhanced accuracy at both low and high flows.Over a 20-year ifespan,your iPERL will measure just as accurately as the day it was ._ Insstalled. Solid State Magnetic Technology By avoiding the use of a mechanical measuring element inside the flow tube, metering performance is linear over the entire flow range- ■ M x:mite m; ensuring no reduction in accuracy at any flow rate over the life of the t_cnrolo c. e, vers a 2 meter.The iPERL meter uses our patented remanent magnetic field technology requiring far less energy and delivering superior accuracy. Alarms • e _. =acvr �...� Quick resolution of tleld issues is made possible with rh co f c,lr hle i - � smart water alarms including leak detection ',- magnetic .magnetic tamper and low battery When integr atri. communication network, remotely gathering and transmia,ng u never been more reliable or profitable. Construction The iPERL meter body is made of composite alloy and contains no material. Inside the meter body is an electronic register and a meas device that is comprised of a composite alloy flow tube. Embed, - in the flow tube are coated silver electrodes. IPERL utilizes these to measure the fluid velocity through the flow tube-enabling less power consumption and predictable meter performance.The IPERL meter has a 20-year accuracy warranty and a 20-year battery life guarantee. • 'Ensu' a xylem brand Page 116 of 427 Agenda Item #9. 66 iPERL Smart Water Meter IIIElectronic Register Conformance to Standards The 9-digit hermetically-sealed electronic register The Sensus iPERL meter meets the requirements -- with LCD display was designed to eliminate dirt, NSF 61 Annex F/G and 372 and exceeds the most fog and moisture contamination in pit settings.The recent revision of AWWA Standard C-715. large, easy-to-read display includes AMR digits, Tamper Resistant direction of flow, units of measure and smart water alarms.The AMR digits and units of measure are fully The integrated construction of the iPERL water mete prevents removal of the register to obtain free water programmable.The register also provides integrated customer data logging. The magnetic tamper and low field alarms will both indicate any attempt to tamper with the magnetic fie AMI /AMR Compatibility of the iPERL meter. Sensus iPERL meters are compatible with common AMR/AMI systems, including the Sensus FlexNete communication network.1I seated \NM I 9 ri t ,ii Reg stet no 5 3/4 n (146 mm) i Magnetic ANINA Flow Sensors or '4110: Allaiim 11111111111111(1�1-1i I smmol Of�O 11114-..s, ..,,Al lc 111 .10,1 Mtllh A Dimensions and Net Weights ,2C .: - a _mn- `20 ,2 r.'t',,'. ;22.n-, ,r 23 mm _ _-n;' 2. - ; 2 22mn-;, 22":,-1---,-, --r-n' I a 25 rnm ,273-11-n; _ I - ,25 : • sEnsus a xylem brand Page 117 of 427 Agenda Item #9. DAT-A.. SHEET •� iPERL Smart Water Meter • Specifications y f • . - sn5us a xylem brand Page 118 of 427 Agenda Item #9. eil Headloss Curves 5/8"Headloss Curve 314"Headloss Curve 411111 s s 3 t , X ....� A n o o Row Raw I.DmI 5'8"x 3;d'Heaoloss Curve 1 Headloss Curve I s .a .......m.., n A >s a ,o m F.....m.l b se SD• sEnsus • " xylem grand E,. l C.Jl 1EiT l 1O_l A ,:1-IC ,, :.-1073::: t...r'..:'..1., F...t. . J tl......_JF:l h :IC:.l.,h 2:,,RPO,,r'1... Page 119 of 427 Agenda Item #9. DATA SHEET e el OMNITM (R2) Water Meter I `� ! 1-1/2" and 2" OMR2 Meter The OMNI R2 Water Water Meter operation is based on advanced Floating Ball Technology (FBT). ,.�,,,0T,,,N Conformance to Standards • Floating Ball Technology(FBT) The OMNI R2 meter meets and far exceeds the most recent revision of ANSI/AWWA Standard C701 class II standards and exceeds performance criteria for ANSI/AWWA C700 Residential Standard using Sensus Turbo ELECTRONIC REGISTER DISPLAY technology. Each meter is performance tested to ensure compliance.All OMNI meters are NSF/ANSI Standard 61,Annex F and G approved. 1....," -7, Performance /sEnsus\ `sEnsus\ The patented measurement principles of the OMNI R2 meter ensure rk �;xP OOra.00' Ni GDORM greater accuracy,expanded accuracy range and longer service life than GAL XI Lany other comparable class meter.The OMNI R2 meter has no restrictions — — on sustained flow rates within its continuous range.The floating ball • TotalzzationMode y1R/AMIMode measurement technology allows installation in any orientation and flows up to maximum rated capacity without undue wear or accuracy degradation. sEnsus'," •-Ainsus• Construction lowGAL the measuring chamber.The measuring chamber assembly includes the Patented Patented "floating ball" impeller with a coated titanium shaft, hybrid axial bearings, Resettable Test Mode Rate of Flow Mode integral flow straightener and an all electronic programmable register with protective bonnet.The maincase is made from industry proven Ductile Iron with an approved NSF epoxy coating. Maincase features are; easily removable measuring chamber, unique chamber seal to the maincase using a high pressure o-ring,testing port and a convenient integral strainer. OMNI Electronic Register The OMNI R2 electronic register is hermetically sealed with an electronic pickup containing no mechanical gearing.The large character LCD displays AMR,totalization, rate of flow and a resettable test totalizer.OMNI register features include AMR resolution units that are fully programmable and integral resettable accuracy testing feature compatible with UniPro and - Sensus flow verification software.The large,easy-to-read LCD also displays both forward and reverse flow directions.The OMNI R2 electronic register has a 10-year battery life guarantee. III C sEnsus a xylem brand Pagevil t o'f 7 Agenda Item #9. 114 OMNITM R2 • Magnetic Drive Head Loss Curves Meter registration is achieved by utilizing a fully magnetic pickup system.This is accomplished by the — 14 1.5" R2 Pressure Loss Curve with Strainer magnetic actions of the embedded rotor magnets a 12 s 10 and the ultra sensitive register pickup probe.The o 8 . only moving component in water is the"floating ball" F. 6 7 4 N impeller. z 2a. o Measuring Element 0 .751.25 7 15 30 50 80 100 Iso 200 Rate of Flow(GPM) The hydro-dynamically balanced impeller floats between the bearings.The Floating Ball Technology 2" R2 Pressure Loss Curve with Strainer (FBT)allows the measuring element to operate n. 12 virtually without friction or wear,thus creating the N 10 extended upper and lower flow ranges capable on � 8 2 s only the OMNI R2 meter. N 4 0 2 2 Strainer d 0 01.0 1.5 7 15 30 50 80 100 200 250 The OMNI R2 with the "V"shaped strainer uses Rate of Flow(GPM) a stainless steel screen along with Floating Ball Technology(FBT).This creates a design that greatly _ 14 2" R2 Pressure Loss Curve without Strainer improves accuracy, even in difficult settings.A a 12 removable strainer cover permits easy access to the o 1$ 1111 -J screen for routine maintenance. 0 6 3 4 N Maintenance 1,) 2 d o The OMNI R2 meter is designed for easy maintenance. 0 1,0 1.5 7 15 30 50 80 100 200 250 Rate of Flow(GPM) Should any maintenance be required,the measuring chamber and/or strainer cover can be removed 1.5" R2 Accuracy Curve independently. Replacement parts or complete 902 101.5 101 measuring chambers are available for repairs.OMNI 100 ' , ••••••••••pR2 replacement measuring chambers may also m 99 9e.5 3 98 be utilized to upgrade some third-party meters to U 97 achieve increased accuracy and extended service life. a 96 95 0 .751.25 7 15 30 50 80 100 150 200 AMR/AMI Systems Rate of Flow(GPM) Meters and Electronic Registers are compatible with current Sensus AMR/AMI systems and other AMI 2" R2 Accuracy Curve 102 101.5 communication systems that use the Sensus Ull 203 —101 protocol. 100n.........U 992 9893.5 Guarantee u 97 Sensus OMNI R2 Meters are backed by"The Sensus a 96 95 Guarantee."Ask your Sensus representative for 0 1.0 1.5 7 15 30 50 80 100 200 200 details or see Bulletin G-500. Rate of Flow(GPM) 11111 .... .... .... sEnsus a xylem brand Page9�211°o2f9107 i Agenda Item #9. e OMNITM R2 • OMNI R2: 1-1/2"-2" Register with AMR �r__�-e �. �ii����� S'.� ,I !, ,�_' Test Strainer Measuring �� I Plug F j—> �� Cover Chamber � k_ .1 Assemblyr� rIIIIIIMWIlls%'''i �AL ��I'=— ��j� W ijii1iiaii irection . iik:c�N�rat w of Flow —� b000 `41,r'1l• ' v®mtm®®r /�� '�Alit'` 000110000 \ �t�� � •- F Bolt Circle `` ----).0 G-No.of Bolts H-Size of Bolts Strainer Screen Maincase R2 Rotor OMNI R2: 2"Without Strainer 1 D o < A > r Register ���� III � �... ) with AMR • ,I , ` i Measuring 1 Chamber ��i . Assembly .� lirr.f _... iii . �,iio�V —' ..ii rr:�-- �:=�7� \ '/ii��11� All' B k lifiAt. I Direction OLIO* Pik---1 \11\�=�//�j t of Flow \Ot�, I� ir F-Bolt Circle ` \`\\\ ��������\\` \ `� G-No.of Bolts H-Size of Bolts Maincase R2 Rotor Dimensions and Net Weights Opera qe Can-ecrions A B C D E F C H J 1-1,2' DN 2 gpm 150 gpm 13" 7-7/8" 15/16- 5-1/8" 2-5/16" 4" 2 5/8" 1" 18.8.os -- -r;m -' m3/hr 34 m3%hr Flanged 330mrn 200mm 24mm 130mm 59mm 102mm 16mm 25mm 8.53 kg. i 1,1s; _ 5,com 200 gon, 17- 7-7/8" 1- 5-3/4" 2-5/16" 4-1.'2" 2 3/4" 1-1/2" 27.4 lbs. 34.5 311-r 45 m3;br 'ar:ged 432mm 200mm 25rnm 146mrn 59mm '14rnm ":9mm 38mm 12.4 kg. 15 6 u 2"without 2 3/4" N/A 17 lbs. 24 Strainer 2 5 gpm 250f F r' 'Hanged 254mm 200mm 25mm 46mm 59mm1 114mmL19mm 79 kg. DN 30rnm `" ' .11 III .... . .... sEnsus 11 a xylem brand Paged io2f947 I Agenda Item #9. 114 OMNITM R2 Specifications ernent coctaoie -ec - Stnreoe temperature:-22F(-30C)to 155E(63.30 -g temperatures: 2.5 200 PS' Flange Connections US .a'iSl 3 - AVVVVA Class 125 Test Ports Register y electronic sealea register with programroac egist7ar.ion ,Gal./Cu Ft Cu Mt- imp Ga' %A.c e cr' Programmar Guaranteed 1 -year oatteryHie NSF Approved Materia's Maincase: Coated Duct e o Measuring C-=:- ermoplastic Rotor'Floating Bair": aermoplastic Radial Bearings: Hybrid Thermoplastic • Thrust Bearings: Magnets: Sapphire/Ceramic Jewel Ceramic Strainer Screen: Stainless Steel Strainer Cover: Coated Ductile Iron • sEnsus ©2019 Sensus.All products purchased mod services performed are subject to Sensus'terms of sale,available at a xylem m 1,�(..7 ra n P! either sensus.com/TC or 1-800-638-3748.Sensus reserves the right to modify these terms and conditions in l U its own discretion without notice to the customer.The Scotus logo is a registered trademark of Senses. This document is for informational purposes only,and SENSUS MAKES NO EXPRESS WARRANTIES IN THIS DOCUMENT FURTHERMORE,THERE ARE NO IMPLIED WARRAWftES,INCLUDING -- _ WITHOUT LIMITATION,WARRANTIES AS TO FITNESS FOR A PARTICULAR PURPOSE AND r - MERCHANTABILITY.ANY USE OF THE PRODUCTS THAT IS NOT SPECIFICALLY PERMITTED HEREIN IS PROHIBITED. Page 123 of 427 Agenda Item #9. DATA SHEET 41114 • # __ OMNIrnnCompound (C2) r . Water Meter 1-1/2", 2", 3", 4", 6", 8" and 10" OMNI C2 Meter The OMNI Compound (C2) Water Meter operation is based on advanced Floating Ball Technology (FBT). DESCRIPTION. Conformance to Standards The OMNI C2 meter meets and far exceeds the most recent revision of ■ Floating Ball Technology(FBT) AWWA Standard C701 and C702 class II.Additionally,the meter does not require a valve to meet these standards. Each meter is performance tested to ensure compliance.All OMNI meters are NSF/ANSI Standard ELECTRONIC REGISTER DISPLAY 61,Annex F and G approved latest standards. Performance The patented measurement principles of the OMNI C2 meter ensure /s2nsus > s€nsus\ „q greater accuracy, expanded accuracy range and longer service life than OP-1,p-1 . 00,004 • GA r( any other comparable class meter.The OMNI C2 meter has no restrictions , Peented on sustained flow rates within its continuous range.The floating ball measurement technology allows installation in any orientation and Totalization Mode +11/1R/AMI Mode flows up to maximum rated capacity without undue wear or accuracy degradation. "sEnsus\ /sEnsus\ Construction 0,000.00 I CO 3ifil The OMNI C2 meter consists of two basic assemblies; the maincase and I GAL the measuring chamber.The measuring chamber assembly includes the �; � Mffirderl "floating ball" impeller with a coated titanium shaft, hybrid axial bearings, Resettable Test Mode Rate of Flow Mode integral flow straightener and an all electronic programmable register with protective bonnet.The maincase is made from industry proven Ductile Iron with an approved NSF epoxy coating. Maincase features are; easily removable measuring chamber, unique chamber seal to the maincase using a high pressure o-ring,testing port and an AWWA compliant strainer. • sEnsus a xylem brand Page 9 cie,f 7 Agenda Item #9. DATA S H E E OMN r c2 • OMNI Electronic Register Strainer g The OMNI C2 electronic register is hermetically The OMNI C2 with the AWWA compliant"V"shaped sealed with an electronic pickup containing no strainer uses a stainless steel screen along with mechanical gearing.The large character LCD Floating Ball Technology(FBT).This creates a design displays AMR,totalization, rate of flow and a that greatly improves accuracy,even in difficult resettable test totalizer.OMNI register features settings.A removable strainer cover permits easy include AMR resolution units that are fully access to the screen for routine maintenance. programmable,fully programmable pulse output frequency, integral customer data logging capability Maintenance and integral resettable accuracy testing feature The OMNI C2 meter is designed for easy compatible with UniPro and Sensus flow verification maintenance.Should any maintenance be required, software.The large,easy-to-read LCD also displays the measuring chamber and/or strainer cover can both forward and reverse flow directions.The OMNI be removed independently. Replacement parts or C2 electronic register has a 10-year battery life complete measuring chambers are available for repairs.OMNI C2 replacement measuring chambers guarantee. may also be utilized to upgrade some third-party Magnetic Drive meters to achieve increased accuracy and extended Meter registration is achieved by utilizing a fully service life. magnetic pickup system.This is accomplished by the AMR/AMI Systems magnetic actions of the embedded rotor magnets and the ultra sensitive register pickup probe.The only Meters and Electronic Registers are compatible with • moving component in water is the"floating ball" current Sensus AMR/AMI systems and other AMI communication systems that use the Sensus U11203 impeller. protocol. Measuring Element The hydro-dynamically balanced impeller floats Guarantee between the bearings.The Floating Ball Technology Sensus OMNI C2 Meters are backed by"The Sensus (FBT)allows the measuring element to operate Guarantee."Ask your Sensus representative for virtually without friction or wear,thus creating the details or see Bulletin G-500. extended upper and lower flow ranges capable on only the OMNI C2 meter. • sEnsus a xylem brand ` Page9 'Of'2f7 Agenda Item #9. ri OMNITM C2 ID OMNI C2: 1-1/2" D > c A r Register with41 _ WWI1. Pulse and AMR ti rr A Strainer Measuring 11 —� Cover Chamber ;I kr-n Test -' __ Assembly ��. iwim-;i I1 Plug • ig_-rte— 1 a \, 1�1 ��= moi►� il'���,% ;r�����. � -r��+, F j 0®01 `, :_ fit; B Ii �I V 1000 \������� '� +0004 & � �—+�\�\\�`���: sc'°%0011000 '__�_ / It♦ n...... /► Directions ��� �1 4®ma/001 of Flow 0000 rriiiniI1...i .. 0001 NMI F Bolt Circle G-No.of Bolts ÷ 4—C Strainer H-Size of Bolts Screen Maincase C2 Rotor OMNI C2:2" D > < A > Register with • r1 R Pulse and AMR IT Strainer Measuring j Cover Chamber l'm.�iTest F �� Assembly ,�I jr �ryT%', PtugsililralliIIII i lip ®001 �`�a� +��, , ',A. d_ip B ''' - 1' 1 000 \` c.!mot 19 t1. 0001 .`"!'� \\ �-/ ��� 1000 — ft 0001000 / Directions .,r n l ±_'r,�I� ,®®�r001 VP W of Flow 1000 .+��!���!114 4 A a, 0001 \. illiF Bolt Circle G- No.of Bolts -J4—C Strainer H -Size of Bolts Screen Maincase C2 Rotor 1 II sEnsus a xylem brand Page 9 dof i07 Agenda Item #9. DA <.-, e OMNITM C2 • OMNI C2: 3"-6" D > < A Register with ig b 4 Pulse and AMR �1 ,:-- Strainer Measuring i ; Test .,1-> Cover Chamber ,I 'fir-Plug . A �- Assembly �i A T ,—_; �. /��� �� i .1ou �% iiai� \.��. \...,1/4 .000000 ,,; ` _ k`:\ NNE\ 0000001 \\� p��\\���---�_ \�� �\O\\\�� .. .000000 X0000'� -0000001 B / 00011000\ .000000 o a� *ua o, Direction 000 000. •• ,�) Ott T 00000`00000, of Flow000000' ,%T^`4 \1000+�100001� .000000 �1. E \\\\\\ �o.......o\\\\\ �000000. -�L►� \ �' \ \: .000A0.00.0. ; \\\,—,,, o,.--,z7.............o 000.001 I F-Bolt Circle G-No.of Bolts \ Strainer 'V H-Size of Bolts 14—C Screen Maincase C2 Rotor OMNI CH 8" 10" D < A Register with Pulse and AMR Test Strainer Measuring Plug J 4 ► -->C- Cover Chamber Ill Assembly _ NINA r. .i nue .. ��. m T n u. 4111 in/ Nu ip til 1111110 �' lair . o o • ��/ 1111w1liplA / 00 . 00 . mu11000000 . 1111111 000 1 000 , 11me01/O o000000o O1111111110000000011un0 / B• 00000000 • 11111111 0000 �� 0000 11uw0000000000Direction_ 1111111 �� _ .i T0°0°0°0°0 0°0°0°0°0 of Flow11uuU �,� "',,,;0000 X10000 11nm. 00000000 11nuu. 000 1000 1111mL \O 00000000 O 11111,11E 000 00011n111°•°o°°��°o°° �1iiIi1i1✓. ' F-Bolt Circle Maincase C2 Rotor G-No.of Bolts H-Size of Bolts Strainer Screen r • sEnsus a xylem brand Page9 'of74)7 Agenda Item #9. - - - •e OMNI"" C2 IDDimensions and Net Weights Meter Nv'ma! and Pipec -_..s A D _ = G H S: Operating acg" gpm 200C _ _ � 5-7'16' 2-5.-6' w' 2 330mm 2: _ 38mm 59mn 02mm 2 1 15-1/4" 77.3' 5-3/4" 2-5/16" 4-1/2" 2 3,4" os 387mm 200mm 25mm 146mm 59mm 114mm 19mm - j-1/8 c' 5/8" - _ . 05mm -152mm 4 16mm 25mr _ , y 5 gpm --3/4" 7-1/2" 8 5/8" 1-1/2" 04 / bs. 72 o• ,m 34 m3'hr 22: 2.17, 141mm 16mm 38mm 29.44 kg. 33.02 6"DN 3 gpm 2000 gpm 2" 8 3/4" 1-1/2" 130 lbs. 155 lbs. 50mm .68 m3/hr 454 m3 m mrn 19mm 38mm 59.0 kg. 70.3 kg. 3' DN 4 gpm 2700 gpn-i 30-1/8' 3 3/4" 2' 471 lbs. 521 lbs. 200mm .91 m3/hr 614 m3/1-,r Flanged 765mm 381mm _ 19mm 51mm 214 kg. 236 kg. 1 5 gom j 41-1/8" 7/8" 2" 685 lbs. 745 lbs- .' m 3 '. m n - -„ 51mm 311 kg. 338 kg. Specifications ure poabie and reclaim water. Pressure Loss 1-1/2":6.9 psi @ 160 GPM(0.48 bar @ 36 m3/hr) Storage temperature: 2":4.3 psi @ 160 GPM(0.30 bar @ 36 m3/hr) -22F(-30C)to 155F(68.3C) 3":3.2 psi @ 400 GPM(0.22 bar @ 91 m3/hr) Operating temperatures: 4".6.4 psi @ 800 GPM(0.44 bar @ 182 m3/hr) Air:-22F(-30C)to 150F(65.6C) 5.5 psi @ 1600 GPM(0.38 bar @ 363 m3/hr) Water:33F(0.6C)to 80F(26.7C) 8":4 psi @ 2700 GPM(0 28 bar @ 614 m3/hr) 10":4.5 psi @ 4000 GPM(0.31 bar @ 908 m3/hr) OperaCCng 1-1/2":0-5-200 GPM(0.11 -45 m3/hr) Range 2":0-5-200 GPM(0.11 -45 m3/hr) Maximum 200 PSI(13.8 bar) ''0%* 1 5%) 3": 1.0-500 GPM(0-23-114 m3/hr) Operating 4': 1.5-1000 GPM(0.34-227 m3/hr) Pressure 6':3-2000 GPM(0.68-454 m3/hr) 8":4-2700 GPM(0.9'! 614 m3�hr) Flange U.S ANSI B16' -5,iJWA Class 125 10':5-4000 GPM(1.1 -908 m3/hr) Connections Test Ports N°T mow Sow 1-1/2'0.25 GPM(.06 m3/hr) (95%-1010.25 GPiv'(.06 m3./hr) Register register 3"-0.5 GPM(0 11 m3/hr) programmable registration 41.0.75 GPM(0.17 m'Inr) (Gal./Cu Ft./Cu.Mtr.;imp.Ga 6". 1 5 GPM(0.34 m3 'nr) Programmable AMRAMI reading and GPM 1 8":2.., (0-57 rn31nr) pulse outputs 1 2-53 ''' Gua oved Paa 2 - '66 i(36 m32,3-) s Meas .ny 3 400 GPM(91 m3..'nr) Rott> 4":800 GPM(182 m3/hr) Rac r" 1600 GPM(363 m3 Tnru. 8' 2700 GP^:j1(614 m3 - ° Jewel rr3; Magnets: Ceramic Strainer Screen: Stainless Steel Strainer Cover: Coated Duct,,e _. �-' G 4'r 3, Test Plug: Stainless Steel 4": 1000 GPM(227 m3 6":2000 GPM(454 m3;.- 8":3400 GPM(773 n,3i-, In':5000 • I sEnsus a xylem brand Page9�lWof' 7 Agenda Item #9. ♦e OMNIrm C2 0 Head Loss Curves 1.5" C2 Pressure Loss Curve with Strainer 1.5" C2 Accuracy Curve 14 102 101.E QQ, 12 —101 3 100 41.. ..a 10 a T J 8 ` 99 1 98.E d 6 7 98 7 4 p 97 as 2 Q 96 d 0 95 0 .5 1.5 9 30 80 130 200 200 0.25 1 7 15 30 50 80 100 160 200 Rate of Flow(GPM) Rate of Flow(GPM) 2" C2 Pressure Loss Curve with Strainer 2" C2 Accuracy Curve C 14 102 - - — -101.0 0. 12 —101 a 10 2 100 v '' '......Minmr.r. ' a J 8 m :: 9 - 98.E E 6 _ 98 a 4 Q 97 a• 2 96 _ 0 95 a 0 1.0 1.5 7 15 30 50 80 100 200 250 0.25 1 7 15 30 50 80 100 160 200 Rate of Flow(GPM) Rate of Flow(GPM) 3" C2 Pressure Loss Curve with Strainer 3" C2 Accuracy Curve C 14 102 101.5 a 12 —101 J 10 °100 1.......1.......a J 8 a 99 93.5 0 •® 8 7 98 3 4 8 97 m2 Q 96 11 0 ......'% 95 0 .5 1.0 10 50 100 200 300 400 500 650 Rate of Flow(GPM) Rate of Flow(GPM) 4" C2 Pressure Loss Curve with Strainer 4" C2 Accuracy Curve 14 102 101.5 0_ 12 -7,,101 a 10 °100 I+^ a J 8 a 99 98.5 E, 0 v98 3 4 U 97 a 2 Q 96 a Q. 0 95 0 10 50 100 200 300 600 1000 0 1 1.5 10 50 100 200 300 600 1000 1250 Rate of Flow(GPM) Rate of Flow(GPM) 6" C2 Pressure Loss Curve with Strainer 6"C2 Accuracy Curve C 14 102 101.5 a 12 —101 aa 10 T 100 J 8 m i 99 - . — . - . 93.5 6 98 a 4 Q 97 8 2 96 a 0 95 0 25 50 100 500 1000 1500 2000 251 0 1.5 3.0 25 50 100 500 1000 1500 2000 2500 Rate of Flow(GPM) Rate of Flow(GPM) 0 sEnsus a xylem brand Page`19Of 4'27 Agenda Item #9. el' OMNr c2 IIIHead Loss Curves 8"C2 Pressure Loss Curve with Strainer 8"C2 Accuracy Curve 7 102 10'.5 n 101 . 100 ~—' T R 99 9E.5 6 98 u 97 Q 95 a 0 0 25 50 100 500 1000 2000 3000 0 3 6 25 50 100 500 1000 2000 3000 2500 Rate of Flow(GPM) Rate of Flow(GPM) 10"C2 Pressure Loss Curve with Strainer 10"C2 Accuracy Curve 7 102 101.5 d 6 --.101 CI) 6 °100 mom..., O J 5 U 99 ta 91.5 d 4 U 98 y 3 Q 97 to 2 96 d L 0 95 0 25 50 100 500 1000 2000 3000 4000 0 3 6 25 50 100 500 1000 2000 3000 4000 2500 Rate of Flow(GPM) Rate of Flow(GPM) 110 4111/ sEnsus ©2019 Senses.All products purchased and services performed are subject to Senses'terms of sale,available at a xylem brand either aesus.com/TC or 1-000-638-3748.Senses reserves the right to modify these terms and conditions in its awn discretion without notice to the customer.7lte Senses logo is a registered trademark of Senses. __ -D, This document is for informational purposes only,and SENSUS MAKES NO EXPRESS WARRANTIES is .,e IN THIS DOCUMENT.FURTHERMORE,THERE ARE NO IMPLIED WARRANTIES,INCLUDING „,,-:5./; F,(;'^_. - WITHOUT LIMITATION,WARRANTIES AS TO FITNESS FOR A PARTICULAR PURPOSE AND 38 :2,718 MERCHANTABILITY.ANY USE OF THE PRODUCTS THAT IS NOT SPECIFICALLY PERMITTED HEREIN IS PROHIBITED. rr Page 130 of 427 Agenda Item #9. • SmartPoint 520M Pit Set Module - The SmartPoint' 520M Pit Set Module is a radio transceiver • that provides water utilities inbound and outbound access to water measurement and ancillary device diagnostics •'!:' - it via radio signal. The SmartPoint 520M is designed for .: iii submersible, pit-set environments. TouchCoupler Design S the encopec "'titer. VVI;n loucn I.VUp1i. file .)!I id,a Vit ti„ z_l/r4I I` - can connect to the meter using existing tvvo wire AMR installations instead of requiring utilities to access the wine connect'on.MS+eSuitS in a fast, eific'- minimal cost. 0t ,,,, Operation em _ With its migratabie, two-way communication ability. the M SmartPoint functions as a walk-by/drive-by endpoint exec-bus, I endpoint, or colrlbination of the two.This flexibility increase_ cosi ction caoabliities and streamlines operations.TI- ■ Modnie re eves ,nput from the meter to a valiK-ov cr ve-'by or <ed-bast In w 'r ry e-by mode the naltPcin_520N1 H_o • , and awaits an cct .tion s anal fro— - - (`✓GB)or Ha ib-He ; Devi: (HHD) read,nos toe meter ,den it=cation ". As . fixed 'base endpoint,the SmartPoint 520M Module Intel acts Or more st.atec;Icai y placed Base Stations coca ed In the ut,i,v,, _e •,,cu a,eq. Top of the noL;r readings and other diagnostics are in-i' to the Reclonal Network Interface(RNI)- at t FlexNet"communication network provides unmatched rehab expansive tower receiver coverage of metering end points.data redundancy, railover backup provisions and operateprimary Lisir': I. • (unshared)RF spectrum. sEnsus a xylem brand Page 131 of 427 • Agenda Item #9. 's.. SmartPoint 520M • Pit Set Module • Powerful Transmission, Flexible Platform readings and can monitor continuous flow over a The SmartPoint'520M Pit Set Module offers several programmable period of time, alerting the utility to advantages that control both deployment and leak conditions. In addition,the SmartPoint stores lifetime operation costs. Its powerful. industry- up to 840 consumption intervals(35 days of hourly leading two watt transmitter broadcasts over large consumption), providing the utility with the ability distances and minimizes collection infrastructure to extract detailed usage profiles for consumer And after the SmartPoint is installed, its migratab e. information and dispute resolution.The SmartPoint two-way system platform can be updated without also incorporates a two-port design, allowing the requiring personnel to visit each meter and/or utility to connect multiple registers and ancillary inconveniencing customers. devices(such as acoustic monitoring)to a single SmartPoint.This results in a compact installation that Additional Smartpoint 520M Module Features saves time,space and money- without reducing The SmartPoint 520M Module obtains houriy system performance. Specifications mer.e`*_ =.exN tcorn muncat',e, e.t:v_ . . 't • • • sEnsus :- O 020:9 Sesus.All products purchased and services performed are subject to Seosus terms of sale,available at a xylem brand either sensus.com/TC or i-800-038-3748.Sensus reserves the right to modify these terms and conditions i:: its own discretion without notice to the customer The Senses:ago is a registered tnuienmrk of Senstts - This document is for informational purposes only,and SENSUS MAKES NO EXPRESS WAR.RAiI: ES IN THIS DOCUMENT.FURTHERMORE,THERE ARE NO IMPLIED WARRANTIES,INCL1_ L1M1'1'A'1'ION,WARRANTIES AS'1'O FITNESS FORA PARTICULAR PURPCS MERCHANTABILITY ANY USE OF THE PRODUCTS THAT IS NOT SPECIFICALLY PEI; HEREIN 1S PROHIBITED. Page 132 of 427